Investigation of One-Dimensional PAN/SrTiO3@Al Composite Nanofibers for Hydrogen Evolution
DOI:
https://doi.org/10.18321/ectj1697Keywords:
Nanofiber, Electrospinning, Photocatalyst, SrTiO3, Hydrogen evolutionAbstract
The development of promising photocatalysts for hydrogen production is one of the most important areas of research. Enhanced efficiency can be achieved by modifying the composition and creating composite structures, thereby improving the separation of photogenerated charge carriers. In this work, SrTiO3 (STO) and Al-doped SrTiO3 (SrTiO3@Al; hereafter denoted as ASTO) photocatalysts were synthesized, followed by the incorporation of Rh-, Cr-, and Co-containing cocatalysts to obtain ASTO@Rh/Cr/Co. Polyacrylonitrile (PAN)-based composite nanofibers containing the corresponding photocatalysts were prepared by electrospinning followed by carbonization. The synthesized materials were characterized by scanning electron microscopy (SEM) and Fourier-transform infrared (FTIR) spectroscopy, while their photoelectrochemical properties were evaluated using photocurrent measurements. The photocatalytic properties of the composites were investigated in hydrogen evolution reactions. The hydrogen evolution rate of the PAN/ASTO@Rh/Cr/Co composite was found to be 319.5 μmol·g–1·h–1, which is 1.96 times higher than that of PAN/STO and 6.64 times higher than that of the PAN/ASTO composite. These results demonstrate that the incorporation of Rh/Cr/Co cocatalysts into the PAN/ASTO composite substantially enhances photocatalytic hydrogen evolution under the investigated experimental conditions.
References
(1) B. Abhishek, A. Jayarama, A.S. Rao, et al., Challenges in photocatalytic hydrogen evolution: Importance of photocatalysts and photocatalytic reactors, Int. J. Hydrog. Energy 81 (2024) 1442–1466. Crossref
(2) L. Gao, K. Hao, F. Yang, et al., Research on the effect of two-dimensional perovskite crystal structures on photocatalytic hydrogen production, Mater. Lett. 371 (2024) 136967. Crossref
(3) X. Pan, H. Zhou, D. Baimbetov, et al., Development Status and Future Prospects of Hydrogen Energy Technology: Production, Storage, and Cost Analysis, Adv. Energy Sustain. Res. 6 (2025) 2400451. Crossref
(4) A. Mehtab, S.A. Ali, I. Sadiq, et al., Hydrogen Energy as Sustainable Energy Resource for Carbon-Neutrality Realization, ACS Sustainable Resour. Manag. 1 (2024) 604–620. Crossref
(5) A. Serik, N. Idrissov, Z. Kuspanov, et al., Impact of water matrix type on the efficiency of photocatalytic degradation of organic pollutants, Catal. Today 477 (2026) 115934. Crossref
(6) P.-A. Le, V.D. Trung, P.L. Nguyen, et al., The current status of hydrogen energy: an overview, RSC Adv. 13 (2023) 28262–28287. Crossref
(7) D. Utarova, N. Idrissov, K. Askaruly, et al., Rice husk-derived AC/MgAlFe-LDH composite for rose Bengal removal from real water matrices, Carbon Trends 24 (2026) 100677. Crossref
(8) J. Incer-Valverde, A. Korayem, G. Tsatsaronis, T. Morosuk, “Colors” of hydrogen: Definitions and carbon intensity, Energy Convers. Manag. 291 (2023) 117294. Crossref
(9) P. Saha, F.A. Akash, S.M. Shovon, et al., Grey, blue, and green hydrogen: A comprehensive review of production methods and prospects for zero-emission energy, Int. J. Green Energy 21 (2024) 1383–1397. Crossref
(10) R. Roy, G. Antonini, K.S. Hayibo, et al., Comparative techno-environmental analysis of grey, blue, green/yellow and pale-blue hydrogen production, Int. J. Hydrog. Energy 116 (2025) 200–210. Crossref
(11) N. Johnson, M. Liebreich, D.M. Kammen, et al., Realistic roles for hydrogen in the future energy transition, Nat. Rev. Clean Technol. 1 (2025) 351–371. Crossref
(12) A.O.M. Maka, M. Mehmood, Green hydrogen energy production: current status and potential, Clean Energy 8 (2024) 1–7. Crossref
(13) A. Israr, M. Saadat, A. Israr, et al., Green hydrogen energy, current trends, challenges and future developments, Sustain. Energy Technol. Assess. 86 (2026) 104886. Crossref
(14) F. Kourougianni, A. Arsalis, A.V. Olympios, et al., A comprehensive review of green hydrogen energy systems, Renew. Energy 231 (2024) 120911. Crossref
(15) A.G. Al-Gamal, F. Yehia, M.R. Elmasry, et al., Perovskite materials for hydrogen evolution: Processes, challenges and future perspectives, Int. J. Hydrog. Energy 79 (2024) 1113–1138. Crossref
(16) I.M.S. Anekwe, S.I. Mustapha, S.O. Akpasi, et al., The hydrogen challenge: addressing storage, safety, and environmental concerns in hydrogen economy, Int. J. Hydrog. Energy 167 (2025) 150952. Crossref
(17) X. Zhu, Y. Liu, M. Wang, et al., Boosting solar photothermal synergy for efficient overall water splitting based on Mg, Al codoped and Rh/Cr2O3/CoOOH coloaded SrTiO3, Chem. Eng. J. 479 (2024) 147636. Crossref
(18) M.M. Phasha, K.E. Ramohlola, R. Mhlaba, K.D. Modibane, Metal-organic frameworks for advancing photocatalytic and electrocatalytic hydrogen evolution, J. Environ. Chem. Eng. 13 (2025) 119594. Crossref
(19) M. Kumar, N.K. Singh, R.S. Kumar, R. Singh, Production of Green Hydrogen through Photocatalysis, in: A. Kumar (Ed.), ACS Symp. Ser., American Chemical Society, Washington, DC, 2024: pp. 1–24. Crossref
(20) L. Guo, M. Xu, L. Niu, et al., Electrospinning Synthesized Cd0.3 Zn0.7 S@PVDF/PAN Piezoelectric Nanofiber Membrane for Efficient Photocatalytic Hydrogen Evolution, Rare Met. 45 (2026) e70147. Crossref
(21) M. Ganapathy, C.T. Chang, V. Alagan, Facile preparation of amorphous SrTiO3- crystalline PbS heterojunction for efficient photocatalytic hydrogen production, Int. J. Hydrog. Energy 47 (2022) 27555–27565. Crossref
(22) S. Odabasi Lee, H.S. Moon, I. Hong, et al., Hollow SrTiO3 photocatalyst with spatially separated OER and HER cocatalysts for photocatalytic overall water splitting, Appl. Surf. Sci. 665 (2024) 160298. Crossref
(23) Q. Kuang, S. Yang, Template Synthesis of Single-Crystal-Like Porous SrTiO3 Nanocube Assemblies and Their Enhanced Photocatalytic Hydrogen Evolution, ACS Appl. Mater. Interfaces 5 (2013) 3683–3690. Crossref
(24) M. Guo, J. Zhong, W. Li, et al., Highly-efficient photocatalytic hydrogen evolution enabled by piezotronic effects in SrTiO3/BaTiO3 nanofiber heterojunctions, Nano Energy 127 (2024) 109745. Crossref
(25) M. Zhang, E.M. Lopato, N.N. Ene, et al., Synthesis and Structure of an Ion‐Exchanged SrTiO3 Photocatalyst with Improved Reactivity for Hydrogen Evolution, Adv. Mater. Interfaces 10 (2023) 2202476. Crossref
(26) R. Konta, T. Ishii, H. Kato, A. Kudo, Photocatalytic Activities of Noble Metal Ion Doped SrTiO3 under Visible Light Irradiation, J. Phys. Chem. B 108 (2004) 8992–8995. Crossref
(27) Y. Bi, M.F. Ehsan, Y. Huang, et al., Synthesis of Cr-doped SrTiO3 photocatalyst and its application in visible-light-driven transformation of CO2 into CH4, J. CO2 Util. 12 (2015) 43–48. Crossref
(28) H.-C. Chen, C.-W. Huang, J.C.S. Wu, S.-T. Lin, Theoretical Investigation of the Metal-Doped SrTiO3 Photocatalysts for Water Splitting, J. Phys. Chem. C 116 (2012) 7897–7903. Crossref
(29) Y. Guo, X. Qiu, H. Dong, X. Zhou, Trends in non-metal doping of the SrTiO3 surface: a hybrid density functional study, Phys. Chem. Chem. Phys. 17 (2015) 21611–21621. Crossref
(30) A.A. Wilson, B. Moss, A.A. Riaz, et al., Long-Lived Hole Accumulation in Al:SrTiO3 /Rh–Cr Photocatalyst Systems under Continuous Irradiation and Its Correlation with Overall Water Splitting Efficiency, J. Am. Chem. Soc. 147 (2025) 34438–34448. Crossref
(31) M. Sohrabian, V. Mahdikhah, E. Alimohammadi, et al., Improved photocatalytic performance of SrTiO3 through a Z-scheme polymeric-perovskite heterojunction with g-C3N4 and plasmonic resonance of Ag mediator, Appl. Surf. Sci. 618 (2023) 156682. Crossref
(32) M. Cai, Y. Chen, Z. Zhuo, et al., Construction of SrTiO3/Ti3C2/TiO2 Z-scheme derived from multilayer Ti3C2 MXene for efficient photocatalytic overall water splitting, J. Alloys Compd. 1010 (2025) 177550. Crossref
(33) X. Yu, J. Wang, X. Fu, et al., Construction of Z-scheme SrTiO3/Ag/Ag3PO4 photocatalyst with oxygen vacancies for highly efficient degradation activity towards tetracycline, Sep. Purif. Technol. 241 (2020) 116718. Crossref
(34) T. Kuru, A. Sarilmaz, E. Aslan, et al., Rational design of ZnO/SrTiO3 S-scheme heterojunction for photo-enhanced piezocatalytic hydrogen production, Appl. Surf. Sci. 682 (2025) 161704. Crossref
(35) Zh. Kuspanov, A. Serik, A. Baratov, et al., Efficient Photocatalytic Hydrogen Evolution via Cocatalyst Loaded Al-doped SrTiO3, Eurasian Chem.-Technol. J. 26 (2024) 133–140. Crossref
(36) D.-T. Luu-Dang, N.M. Tran, H.N.-D. Huynh, et al., Investigation of Al doped Rh@Cr2O3/SrTiO3 photocatalysts in overall seawater splitting with the synergetic electron mediators, J. Taiwan Inst. Chem. Eng. 169 (2025) 105971. Crossref
(37) U. Sajid, R. Sun, Y. Xia, K. Chang, Highly crystalline Al-doped SrTiO3 precursor enabled surface Cr, V co-doping for efficient visible-light photocatalytic overall water splitting, Ceram. Int. 52 (2026) 43409–43422. Crossref
(38) L.L. Rusevich, E.A. Kotomin, G. Zvejnieks, et al., Effects of Al Doping on Hydrogen Production Efficiency upon Photostimulated Water Splitting on SrTiO3 Nanoparticles, J. Phys. Chem. C 126 (2022) 21223–21233. Crossref
(39) D.H.K. Murthy, V. Nandal, A. Furube, et al., Origin of Enhanced Overall Water Splitting Efficiency in Aluminum‐Doped SrTiO3 Photocatalyst, Adv. Energy Mater. 13 (2023) 2302064. Crossref
(40) Z. Zhao, E.J. Willard, H. Li, et al., Aluminum enhances photochemical charge separation in strontium titanate nanocrystal photocatalysts for overall water splitting, J. Mater. Chem. A 6 (2018) 16170–16176. Crossref
(41) Y. Zhang, Z. Wang, W. Li, et al., Al3+ ‐Dependent Anisotropic Facet Tailoring on SrTiO3 Single Crystal for Photocatalytic Overall Water Splitting, Angew. Chem. 137 (2025) e202508114. Crossref
(42) S. Hartati, A. Zulfi, P.Y.D. Maulida, et al., Synthesis of Electrospun PAN/TiO2 /Ag Nanofibers Membrane As Potential Air Filtration Media with Photocatalytic Activity, ACS Omega 7 (2022) 10516–10525. Crossref
(43) L. Jianxin, Y. Hengzhe, C. Xuedi, et al., Review of electrospinning technology of photocatalysis, electrocatalysis and magnetic response, J. Mater. Sci. 59 (2024) 10623–10649. Crossref
(44) L. Zhang, Y.-L. Hsieh, Nanoporous ultrahigh specific surface polyacrylonitrile fibres, Nanotechnology 17 (2006) 4416–4423. Crossref
(45) Y. Chen, H. Zhang, K. Liu, et al., Photocatalytic activities of Bi2O2CO3/g-C3N4@PAN nanofibers in hydrogen production, Appl. Surf. Sci. 599 (2022) 154013. Crossref
(46) L. Niu, B. Zhang, J. Sun, et al., Fabrication of photocatalytic PAN nanofiber membrane loading with TiO2@RGO by electro-spinning & electro-spraying, Compos. Part B Eng. 266 (2023) 111046. Crossref
(47) R. Suo, L. Xie, J. Liao, et al., Enhanced Charge Separation in a PAN/ZnO Nanocomposite for Promoted Photocatalytic Hydrogen Evolution, ACS Appl. Energy Mater. 7 (2024) 5668–5678. Crossref
(48) N. Sun, Y. Zhang, X. Li, et al., Ultrathin g-PAN/PANI-encapsulated Cu nanoparticles decorated on SrTiO3 with high stability as an efficient photocatalyst for the H2 evolution and degradation of 4-nitrophenol under visible-light irradiation, Catal. Sci. Technol. 12 (2022) 2482–2489. Crossref
(49) X. Sun, J. Li, Y. Wang, et al.,The g-C3N4/Bi2Sn2O7@PAN nanofibes: Enhanced photocatalytic activity in H2 evolution by the formation of heterojunction and in-situ growth, Appl. Surf. Sci. 608 (2023) 155228. Crossref
(50) A. Serik, Z. Kuspanov, M. Bissenova, et al., Effective photocatalytic degradation of sulfamethoxazole using PAN/SrTiO3 nanofibers, J. Water Process Eng. 66 (2024) 106052. Crossref
(51) U. Abdikarimova, A. Serik, D. Yessenkeldina, et al., Impact of fabrication method on the photocatalytic efficiency of PAN/SRTIO₃@AL composite nanofibers, J. Water Process Eng. 78 (2025) 108803. Crossref
(52) P.-S. Konstas, I. Konstantinou, D. Petrakis, T. Albanis, Development of SrTiO3 Photocatalysts with Visible Light Response Using Amino Acids as Dopant Sources for the Degradation of Organic Pollutants in Aqueous Systems, Catalysts 8 (2018) 528. Crossref
(53) L. Müller, P. Hornig, J. Grabow, F.A. Müller, Preparation of SrTiO3 nanocubes by CO₂ laser vaporization (LAVA) and hydrothermal maturation, Nanoscale Adv. 4 (2022) 182–189. Crossref
(54) L. Sabantina, R. Böttjer, D. Wehlage, et al., Morphological study of stabilization and carbonization of polyacrylonitrile/TiO₂ nanofiber mats, J. Eng. Fibers Fabr. 14 (2019). Crossref
(55) J.L. Storck, M. Wortmann, B. Brockhagen, et al., Comparative study of metal substrates for improved carbonization of electrospun PAN nanofibers, Polymers 14 (2022) 721. Crossref
(56) M. Abd Elkodous, A. Aatiqah, G. Kawamura, W.K. Tan, A. Matsuda, Metallic nanoparticles loaded Al–SrTiO₃ supported with RhCr₂O₃ and CoOOH cocatalysts for overall water splitting, Int. J. Hydrog. Energy 47 (2022) 36139–36148. Crossref
(57) Q. Hu, J. Niu, K.-Q. Zhang, M. Yao, Fabrication of Mn-Doped SrTiO3/Carbon Fiber with Oxygen Vacancy for Enhanced Photocatalytic Hydrogen Evolution, Materials 15 (2022) 4723. Crossref
(58) S. Zhang, E. Jiang, J. Wu, et al., Visible-Light-Driven GO/Rh-SrTiO3 Photocatalyst for Efficient Overall Water Splitting, Catalysts 13 (2023) 851. Crossref
(59) D. Hirayama, T. Kawawaki, S. Oguchi, et al., Ultrafine Rhodium–Chromium Mixed-Oxide Cocatalyst with Facet-Selective Loading for Excellent Photocatalytic Water Splitting, J. Am. Chem. Soc. 146 (2024) 26808–26818. Crossref
(60) J. Zhao, S. Yu, Y. Chen, et al., Effects of site-selective doping on the photocatalytic overall water splitting performance of SrTiO3, Int. J. Hydrog. Energy 249 (2026) 156048. Crossref
(61) M. Qureshi, A.T. Garcia-Esparza, G. Jeantelot, et al., Catalytic consequences of ultrafine Pt clusters supported on SrTiO3 for photocatalytic overall water splitting, J. Catal. 376 (2019) 180–190. Crossref
(62) Z. He, D. Chen, S. Ma, et al., Single-atom molybdenum modified ZnIn2S4 nanoflowers for improving photocatalytic hydrogen evolution performance, Appl. Surf. Sci. 697 (2025) 163023. Crossref
Downloads
Additional Files
Published
How to Cite
Issue
Section
