Utilization of Oil Wastes for Production of Road-building Materials

Authors

  • Z. A. Mansurov Department of Chemical Physics, Al-Farabi Kazakh State National University, 95 Karasai Batyr Str., Almaty 480012, Kazakhstan
  • E. K. Ongarbaev Department of Chemical Physics, Al-Farabi Kazakh State National University, 95 Karasai Batyr Str., Almaty 480012, Kazakhstan
  • B. K. Tuleutaev Department of Chemical Physics, Al-Farabi Kazakh State National University, 95 Karasai Batyr Str., Almaty 480012, Kazakhstan

DOI:

https://doi.org/10.18321/ectj374

Abstract

The pollution of environment by oil spills in the process of extraction, refining and transporting of oil is an important ecological problem of oil industry. Composition and properties of the oil sludge and oil contaminated soil taken from the area of Zhetybai – Uzen – Atyrau pipeline failure have been investigated aiming at development of oil waste utilization methods. The offered thermal method of organic fraction extraction allows to decrease the organic fraction content by 15–20%. It is shown that the recovered oil may be used for the bitumen production, and the solid residue – as a component of cold asphalt concrete.

References

(1). Parenago O.P. & Davydova S.L. Ecological problems of oil chemistry. Oil Chemistry, 39 (1), pp.

-13, 1999 (In Russian).

(2). Kireev M.A. & Nadirov N.K. Ecological problems of oil extraction regions of Kazakhstan and ways of theirs solution. Oil & Gas of Kazakhstan, 4, pp. 132-138, 1998 (In Russian).

(3). Mazlova E.A.& Mesheriakov S.V. Ecological characteristics of oil sludges. Chemistry and technology of fuels and oils, 1, pp. 40-42, 1999 (In Russian).

(4). Titus D. Dispose of oily sludge: divide and anquer.Spec. Suppl. “Envision. Eng.”, p. 27, 1990.

(5). Conway M.F. Bench-scale evaluation of asphalt emulsion stabilization of contaminated soils. Journal of Soil Contamination, 2 (2), pp. 1-9, 1993.

(6). Europe Patent ¹ 448335, 1991.

(7). Testa S.M. Chemical aspects of cold-mix asphalt incorporating contaminated soil. Journal of Soil Contamination, 4 (2), pp.1-17, 1995.

(8). Karim G.A., Ishola G. & Hanafi A. The behavior of tar sand fragments in steady streams of the products of combustion of lean CH4-air or H2-air. ASME Journal of Energy Resources Technology, 110, pp. 151-156, 1988.

(9). Mansurov Z.A., Ongarbaev E.K. & Tuleutaev B.K. Non-waste technology of processing of mazut-polluted grounds. Abstr. of 2nd Int. Seminar “The influence of oil production and main oil pipe-line on the environment». Almaty, pp. 44-46, 1998.

(10). Mansurov Z.A. Some applied aspects of combustion chemistry. KSNU Bulletin, physical series, 5, pp. 19-31, 1997.

(11). Mansurov Z.A., Ongarbaev E.K.,Tuleutaev B.K. Kazakhstan Patent ¹ 7304, 1999. Method of cold asphalt concrete mixture production.

Downloads

Published

2000-06-30

How to Cite

Mansurov, Z. A., Ongarbaev, E. K., & Tuleutaev, B. K. (2000). Utilization of Oil Wastes for Production of Road-building Materials. Eurasian Chemico-Technological Journal, 2(2), 161–166. https://doi.org/10.18321/ectj374

Issue

Vol. 2 No. 2 (2000)

Section

Articles

License

You are free to: Share — copy and redistribute the material in any medium or format. Adapt — remix, transform, and build upon the material for any purpose, even commercially.

Eurasian Chemico-Technological Journal applies a Creative Commons Attribution 4.0 International License to articles and other works we publish.

Subject to the acceptance of the Article for publication in the Eurasian Chemico-Technological Journal, the Author(s) agrees to grant Eurasian Chemico-Technological Journal permission to publish the unpublished and original Article and all associated supplemental material under the Creative Commons Attribution 4.0 International license (CC BY 4.0).

Further distribution of this work must maintain attribution to the author(s) and the published article’s title, journal citation, and DOI.

Most read articles by the same author(s)

1 2 3 4 5 6 > >>